CRM Mitchell1, Author at Barrett Performance

2016 Ford F-350 Super Duty
Mileage
189,761
Service Date
2/28/2024
Services Performed
CODES PRESENT: – C1010-13 – CONTINUOUS VACUUM HUB LOCK SOLENOID – CIRCUIT OPEN – CURRENT DTC – B0090-93 – LEFT FRONTAL RESTRAINTS SENSOR – NO OPERATION – NOT CURRENT DTC LEAK: – COOLANT LEAK PRESENT AT COOLANT CROSSOVER BELOW THERMOSTAT HOUSING, FOUND INCORRECT TRANSMISSION COOLER HOSE IN PLACE OF COOLANT-RATED HOSE AT CROSSOVER-TO-TURBO COOLANT FEED LINE, HOSE DISINTEGRATED WHEN TOUCHED, REPLACE HOSE SECTION WITH CORRECT TYPE HOSE – OIL LEAK BETWEEN UPPER OIL PAN AND BLOCK ALL AROUND OTHER NOTES: – AIR FILTER PLUGGED, NOTED EXCESSIVE AMOUNT OF DUST PRESENT IN INTAKE TUBE AND AT INLET OF TURBO AND FOUND HOSE CLAMP LOOSE AT CONNECTION TO LOWER INTAKE – NOTED NO COOLANT IN SECONDARY COOLING SYSTEM. VACUUM TESTED AND PRESSURE TESTED SECONDARY COOLING SYSTEM AND FOUND AIR-TO-WATER INTERCOOLER CRACKED INTERNALLY (KNOWN ISSUE WITH FACTORY PART) AND COOLANT FROM SECONDARY SYSTEM HAS BEEN INGESTED BY ENGINE. RECOMMEND REPLACE INTERCOOLER AND RE-CHECK SECONDARY SYSTEM FOR ANY FURTHER LEAKS – NOTED DELAYED TRANSMISSION ENGAGEMENT FROM PARK TO DRIVE MAJORITY OF TIME – FOUND BROKEN VACUUM HUB SOLENOID PIGTAIL AND CONNECTOR LOOSE IN SOLENOID, REPLACE PIGTAIL AND RETEST TO DETERMINE IF CIRCUIT CODE RETURNS AND FURTHER DIAGNOSIS IS NECESSARY
COOLANT CROSSOVER MANIFOLD – Remove & Reseal – 6.7L Eng – [Includes: R&I Intake Manifold.]
AIR CLEANER ELEMENT – Remove & Replace
CHARGE AIR COOLER – Remove & Replace – Diesel
FOUND RETAINING TAB ON PIGTAIL BROKEN AND PIGTAIL LOOSE. REPAIR PIGTAIL AND RE-TEST
INSTALL
MARTY M. gave our service a 5 star review on 3/3/2024
2016 Ford F-350 Super Duty
Mileage
53,726
Service Date
1/1/2024
Services Performed
TAP MANIFOLD FOR 5/16-24 BOLT
COLBY F. gave our service a 5 star review on 1/1/2024
2004 Dodge Pickup
Mileage
320,127
Service Date
9/2/2023
Services Performed
FUEL FILTER ELEMENT SOLID BLACK AND FUEL IN BOWL DARK. POSSIBLE POOR FUEL QUALITY, PREVIOUS FUEL FILTER WAS RAN TOO LONG. RECOMMEND RUN THIS FUEL FILTER INTERVAL SHORTER AND CHANGE FILTER AT NEXT OIL CHANGE
ENGINE OIL FILTER – Remove & Replace
(Combination) – ENGINE OIL – Drain & Refill
TRANSMISSION OIL FILTER – Remove & Replace – 4WD
TRANSFER CASE OUTPUT SHAFT SEAL – Remove & Replace – Rear
TRANSFER CASE FLUID SERVICE
POWER STEERING PUMP – Remove & Replace – Diesel – [Includes: Test.]
INSTALL POWER STEERING FILTER, REQUIRED FOR PUMP WARRANTY
PITMAN ARM – Remove & Replace – R2500,R3500,4WD – [DOES NOT include alignment.]
WARRANTY NAPA BATTERIES, RELATIVELY NEW DRIVER SIDE BATTERY MEASURED 130CCA OF 850CCA ORIGINAL RATING PASSENGER BATTERY MEASURED 725CCA OF 850CCA ORIGINAL RATING FOUND DRIVER SIDE B+ CROSSOVER CONNECTION NOT TIGHT, CHECK TO SEE IF CROSSOVER CABLE AND CONNECTIONS GOOD
WITH AMMETER INLINE WITH BATTERY GROUND, A 1-1.5 AMP DRAW WAS OBSERVED AFTER ALL MODULES WERE SHUT DOWN. PULLED FUSES ONE AT A TIME AND THE PRIMARY DRAW CONCERN WAS FOUND AT FUSE 51: RADIO/CLUSTER/UNDERHOOD LIGHT CIRCUIT. DRAW DROPS TO 0.090AMPS, WHICH IS STILL ABOVE THE 0.035AMP MAX DRAW LIMIT, BUT IS SIGNIFICANTLY BETTER THAN THE INITIAL 1-1.5AMPS. DISCONNECTING THE UNDERHOOD LIGHT DID NOT CHANGE CURRENT READING SO ISSUE IS LIKELY EITHER AFTERMARKET RADIO STAYING ON, OR CLUSTER IS FAILED INTERNALLY. WILL NEED TO REMOVE DASH COVER AND DISCONNECT RADIO AND THEN CLUSTER TO SEE WHICH DRAWING AN EXCESSIVE AMOUNT OF CURRENT.
CECIL V. gave our service a 5 star review on 9/5/2023
2018 RAM 2500 HD
Mileage
112,630
Service Date
8/16/2023
Services Performed
MODIFY CLUTCH FORK FOR MAXIMUM REARWARD TRAVEL
CLUTCH HYDRAULIC ASSEMBLY – Remove & Replace
JARED G. gave our service a 5 star review on 8/16/2023
2007 Dodge Pickup
Mileage
106,580
Service Date
2/7/2023
Services Performed
CODES PRESENT: P242F – DIESEL PARTICULATE FILTER RESTRICTION – ASH ACCUMULATION P1451 – DIESEL PARTICULATE FILTER PERFORMANCE – ACTIVE VERIFY TRUCK HAS HAD G30 RECALL PERFORMED. CHRYSLER DEALER AND MITCHELL HISTORY VERIFY THAT TRUCK HAS HAD ALL KNOWN OPEN RECALLS PERFORMED. PERFORM STATIONARY DESOOT PROCEDURE. PROCEDURE COMPLETED SUCCESSFULLY, RESET SOOT COUNTERS, CLEARED CODES, P1451 RETURNED DURING TEST DRIVE AFTER DESOOT PROCEDURE. WILL NEED EXHAUST AFTER TREATMENT SYSTEM REMOVED AND SERVICED. FULL VEHICLE INSPECTION: – OIL LEVEL ABOVE MAX FILL LINE LIKELY DUE TO EXCESSIVE ACTIVE REGEN ATTEMPTS WITH PREVIOUS CODES PRESENT. WILL NEED OIL CHANGE. – AIR FILTER AT END OF SERVICE LIFE OR INADEQUATELY FLOWING, PULLS FILTER SERVICE INDICATOR DOWN. STP BRAND OIL FILTER HAS HALF THE PLEAT COUNT OF A WIX/OE FILTER, REPLACE WITH ACCEPTABLE FILTER. – THERMOSTAT IS STICKING OPEN INTERMITTENTLY – SHOCKS WORN OUT, ALL, TRUCK BOUNCES AROUND OVER BUMPS – EXHAUST MANIFOLD GASKET TO CYLINDER HEAD LEAK AT CYLINDER 6 (REAR CYL) CAUSING SQUEAL – TWO OF THREE TIE ROD ENDS IN STEERING LINKAGE HAVE PLAY – STEERING GEAR HAS PLAY AND CLUNKS – UPPER TRACK BAR BUSHING HAS PLAY – DRIVER SIDE BALL JOINTS MODERATE PLAY, PASSENGER SIDES MILD TO MODERATE PLAY – FRONT AXLE JOINTS BEGINNING TO SHOW PLAY – FRONT DRIVESHAFT CV JOINTS MILD PLAY
LABOR IS PROVISIONED FOR POTENTIAL RE-ALIGNMENT AND RE-WELDING OF DOWNPIPE IF CLOCKING IS OFF UPON RETURN FROM SERVICE. LABOR WILL BE REDUCED IF RE-INSTALL GOES SMOOTHLY
AIR CLEANER ELEMENT – Remove & Replace
GUY C. gave our service a 5 star review on 2/7/2023
2012 Ford Pickup
Mileage
109,540
Service Date
1/11/2023
Services Performed
ENGINE OIL FILTER – Remove & Replace – F150
(Combination) – ENGINE OIL – Drain & Refill
FLASH LIVEWIRE TO STOCK, PULL STOCK TUNE WITH HP TUNERS, FLASH EXISTING TUNE BACK ON TRUCK
MAC M. gave our service a 5 star review on 1/12/2023
2016 Ford F-350 Super Duty
Mileage
214,875
Service Date
11/19/2022
Services Performed
REPAIR FAILED EXHAUST SECTION
AIR CLEANER ELEMENT – Remove & Replace
SHAINE H. gave our service a 5 star review on 11/30/2022
2013 Chevrolet Silverado 2500 HD
Mileage
112,705
Service Date
12/14/2021
Services Performed
TRANSMISSION OIL FILTER – Remove & Replace – Diesel Both,Internal,Spin-On – [Includes: R&I Transmission Oil Pan. Includes: Confirm Fluid temperature for level check.] – [Includes: Drain and fill.]
TRANSFER CASE ADAPTER SEAL – Remove & Replace
(Additional) – TRANSFER CASE ADAPTER SEAL – Remove & Replace w/Skid Plate add
POWER STEERING PUMP – Remove & Replace – Diesel w/Single Alternator
POWER STEERING HOSE – Remove & Replace – Diesel Pressure,Pump to Booster – [Includes: Bleed System.]
INSTALL MPROP (REDUCED LABOR RATE DUE TO EASE OF ACCESS WITH SDP INTAKE HORN KIT)
JORDAN D. gave our service a 5 star review on 1/1/2022
We Service and Repair
Most RAM Trucks
Services Performed

All General Repair and Maintenance
We Service and Repair
Most GMC Cars and Trucks
Services Performed

All General Repair and Maintenance

CRM Mitchell1

We Service and Repair all CRM Mitchell1 cars